Ive got until april 13 to figure this out below is a list of things to do, any suggestions comments would be helpful, also im going to have to drive this car from san francisco to orange county, Im going to take the 101 frwy all the way and am looking for emergency stops and garages for each county along the way. area codes are 408, 805, 213, 714, 949... HELP!!!!!
________________________________________
914 Start Up List
Parts- Fuel Filter, Spark pulgs, rotor/cap points, Condenser, Bosh blue coil, Oil/ fliter, Install oil-temp guages, Fire extinguisher Possible throttle sensor switch.
Prestart inspection- Engine compartment- clean out debris, inspect hoses, lines, fan belt, remove air cowling, inspect oil cooling tower, inspect F.I. system hoses lines clamps, distributer wires, coil, quick check-engine for oil leaks-overt damages, inspect transmision-oil leaks, likage etc.
Install new parts- spark plugs, rotor/cap/ pts., blue coil, fuel filter. Adjust and gap all.
Prestart checklist-
Wheels-brakes pads, grease berings, check lines, grease connections, emergency brake cable,(inspect shifter linkage) shocks, oil leaks.
Gas tank- drain, inspect lines/clamps, electrical connections
Headlights- motor assemblies, electrical connections, turn signals, brake lights
Ignition switch- power in all positions, indicator lights, signal lights headlights, listen for fuel tick, tick, tick
Fuse box- Inspection, replace fuses as needed, check other electrical-heater fan wipers etc.
Battery compartment- Clean up with bakeing soda/water, clean terminal ends, repair
Drain oil, refil, Check oil level Wait on install of new filter
Replace any parts as needed
Prelim Start- Fill gas tank 2 gal. W/ fuel inject cleaner, Turn over engine, Listen to starter, Warm to idle, rev to 2500, once running, engage clutch, check gears. After 5 min continious running, stop engine, wait 1-2 min then restart. Repeate. If good, Try slow around block. Once back drain oil, replace oil filter and new oil.
Go through FI checklist, Electrical etc. Install Oil pressure / temp guages
Confidence Runs: around block @ least 5 times. Around town 30 min. run, 30 mile run. Freeway run 1 mile, 5 miles, 20 miles @ 60-70 mph. Check everything after each run.
Final run: 50 mile freeway run, Skyline run. 3 hour run continous. All low stress runs.
Emergency Kit- Duct tape, spare tire in a can, a jack, Fire extinguisher, tools, manual, fuses, spark plug, acellerator cable, AAA card, Cel phone.
Thanks in advance
